PRESOL | Y | Construct a 40 X 96 add on to existing building provide all materials for complete building construction.

FBO DAILY ISSUE OF MARCH 29, 2003 FBO #0484
SOLICITATION NOTICE

Y -- Construct a 40 X 96 add on to existing building provide all materials for complete building construction.

Notice Date: 3/27/2003
Notice Type: Solicitation Notice
Contracting Office: MWR - Black Hills Contracting - Mt Rushmore National Memorial Box 268, Hwy 244 Keystone SD 57751
ZIP Code: 57751
Solicitation Number: I1505030035
Archive Date: 3/26/2004
Point of Contact: Ron Eilefson Lead Contract Specialist 6055743130 Ron_Eilefson@nps.gov;
E-Mail Address: Email your questions to Point of Contact above, or if none listed, contact the IDEASEC HELP DESK for assistance
(EC_helpdesk@NBC.GOV)
Small Business Set-Aside: N/A
Description: Construct a 40 x 96 add on to an existing building. Approximate dimensions = 40 ft. X 96 ft. pole barn construction ? Garage dimensions = 40 ft. X 76 ft. (5 15 ft.- wide bays, 12 ft. tall side walls)? Office area dimensions = 40 ft. X 20 ft.; 10 ft. side walls with 8 ft. drop ceiling Foundation: This building will be built on flat grassland with highly expansive bentonitic clay soil. Based on borings and lab analysis, this building should be supported by drilled pier-grade beam type foundation or supported by spread footing foundations bearing on a minimum of 5 feet of granular engineered fill. The floor will be a concrete slab above grade bearing on a minimum of 5 feet of granular engineered fill. The slab should be above grade in order to facilitate run-off and so that eroded soil from the surrounding badlands will not be deposited against the building structure. General:"Best" locks on all doors; all walk-in doors meet ADA standards, Building should meet UBC Code, NEC, UPC, UMC, UFC, UFAS and ADA regulations.gutters and downspouts front and back, 4" or 5" or to match existing size 2' roof overhang snow load 30psf minimum, wind speed 90mph minimum all windows slide-by with screen, to match existing in manufacture; Insulated glass, thermal break, low "E" double glazed for energy efficiency.4x12 roof slope 4" minimum concrete slab thickness in office/work area, 6" in bays; 4,000psi minimum strip topsoil, over-excavate, at least 24" compacted fill floor level flush to existing radiant heat system; in-floor; separate thermostats for office area and bays; connected to existing heat system government will place utilities within 5 ft. of slabsprinkler system in offices extended from existing.Roofing: galvanized steel, 29 gauge; light gray in color (to match existing building); R22 minimum insulation; vented Siding: galvanized steel, 29 gauge; light gray in color; (to match existing building) Exterior walk-in door: metal, commercial grade, insulated, 3 heavy-duty hinges, in metal frames with weather stripping; R15 minimum; deadbolt lock ; with thermal pane window Exterior walls: R19 minimum insulation (2x6 construction) Interior walls: 2X4 construction; sound insulation in all offices, ?" painted and textured sheet rock, color to be provided by government.Interior doors, 2 (office area): solid core wood commercial grade; 1.5 inch thick minimum; oak veneer finish; lever-type handles; 1 walk-in door between offices and garage: metal, commercial grade, insulated, 3 heavy-duty hinges, in metal frames with weather stripping; R15 minimum; deadbolt lock ; with thermal pane window Lighting (office area): appropriate for office work; energy efficient fluorescent Lighting (garage): suspended energy efficient fluorescent Garage area 5 Overhead drive-in doors 10 ft. X 10 ft.; insulated, commercial grade metal framed door openings Chain lift, electronic operation 2 small windows/door insulated concrete-filled pipe bollards on each side of each door Concrete slab with minimum 4 ft. apron in front of garage bays Concrete pad 6" in depth Drain in 3 of 5 bays to existing oil/sand separator and drain 3 slide-by windows along back wall (centered on bays); 3 ft. X 6 ft. or approximate 2 slide-by windows along end wall; 3 ft. X 6 ft. or approximate radiant heat (hanging from ceiling) on separate programmable thermostat; no AC insulated walls and ceiling (2x6 construction, R22 ceiling; R19 walls) plywood around garage to 8 ft. high,utility sink electrical outlets 18" around 3 sides of bay area to code, office/Work area/Break area smoke detectors HVAC ductwork connected to existing building's HVAC system and extended for proper heating and ventilation. Radiant heat in floor. New office/work area will use the same programmable thermostat as existing office/meeting room; Fire wall separates from garage (if required by code) offices: approximately 10 ft. X 11 ft. each 1 slide by window in each; 3 ft. X 6 ft. finished sheet rock; oak trim; solid, oak-finish doors; suspended ceiling match existing ; recessed lights carpet in offices (2 X approx. 10 ft. X 11 ft.) and in work area (approx. 20 ft. X 20 ft.), and break area (approx. 10 ft. X 20 ft.) 1 slide by window in break area; 3 ft. X 6 ft.1 metal, insulated 3 ft. wide walk-in door w/ half window (insulated glass), handicap access handle to garage All oak trim in office area to match with cupboards ?Plumbing: connected to existing building; 1 kitchen sink; 1 janitor sink in garage bay; 1 frost-free exterior faucet Floor Coverings: commercial grade, low-level loop carpet installed in office/work/break area Cabinets: all oak veneer; counter-tops Formica finish with back splash Telephone/computer jacks: 3 per office; 12 in break/work area. Place a double gang box with a single mud ring reducer 18" above the floor at each location per floor plan. Within the wall, 1 ?" conduit shall be stubbed from the gang box up the wall and be accessible above the drop ceiling for installation of computer/telephone cable by the government on site. motion detector light at walk-in exterior door This building will be built on flat grassland with highly expansive bentonitic clay soil. Based on borings and lab analysis, this building should be supported by drilled pier-grade beam type foundation or supported by spread footing foundations bearing on a minimum of 5 feet of granular engineered fill. The floor will be a concrete slab above grade bearing on a minimum of 5 feet of granular engineered fill. the slab should be above grade in order to facilitate run-off and so that eroded soil from the surrounding badlands will not be deposited against the building structure. This solicitation will be available only by connecting with the DOI Website at (http://ideasec.nbc.gov) No Paper Copies will be submitted.Contractor will be Evaluated on Experience, Past Performance and Price.Solicitation will be available O/A April 11, 2003 and due in this office by 3:00 PM MT on April 28, 2003 NAICS:23320 P&S:Y119 Magnitude of this is betwen $100, 000 and $250,000. This procurement is being conducted in accordance with Public Law 100-656 Small Business Competitiveness Demonstration Program that allows large and small businesses to compete alike.The procurement is being conducted using the rules of FAR 12 Commercial Item purchase and this wil be a "Best Value Procurement"
Web Link: Please click here to view more details.
(http://ideasec.nbc.gov/ecprod/owa/ec$cbd.sypfirstcount?P_SERVER_ID3=NP144302&P_OBJ_ID1=1001670)
Place of Performance: Address: Badlands National Park PO Box 6 Interior, SD 57750 Pennington County; Zip Code: 57751; Country: USA
Record: SN00289494-W 20030329/030327213606 (fbodaily.com)
Source: FedBizOpps.gov Link to This Notice
(may not be valid after Archive Date)

| FSG Index | This Issue's Index | Today's FBO Daily Index Page |

Loren Data's SAM Daily™

Y -- Construct a 40 X 96 add on to existing building provide all materials for complete building construction.