SOLICITATION NOTICE
W -- W-LEASE OR RENTAL OF EQUIPMENT 2/EACH DIESEL POWERED BOOM TRUCKS W/FOAM OR POLY NAIL FREE TIRES AND OSHA TEST CERTIFICATION PAPERS
- Notice Date
- 10/3/2003
- Notice Type
- Solicitation Notice
- Contracting Office
- N69078 CODE N411P BOX 500 BLDG 84/1 NAVAL SUBMARINE BASE NLON Groton, CT
- ZIP Code
- 00000
- Solicitation Number
- N4939903TLIFT
- Response Due
- 10/10/2003
- Archive Date
- 11/8/2003
- Point of Contact
- MARY ANN GERRICK 860-694-4706
- Description
- THIS IS A COMBINED SYNOPSIS/SOLICITATION FOR COMMERCIAL ITEMS PREPARED IN ACCORDANCE WITH THE INFORMATION IN FAR SUPBART 12.6 AS SUPPLEMENTED WITH THE ADDITIONAL INFORMATION INCLUDED IN THIS NOTICE. THIS ANNOUNCEMENT CONSTITUTES THE ONLY SOLICITATION; A WRITTEN SOLICITATION WILL NOT BE ISSUED. THE RFQ NUMBER IS N49399-03-T-LIFTS USING SIMPLIFIED ACQUISITION PROCEDURES FOR COMMERCIAL ITEMS. THIS SOLICITATION DOCUMENT INCORPORATES PROVISIONS AND CLAUSES IN EFFECT THROUGH FAR AND DFARS. IT IS THE CONTRACTOR?S RESPONSIBILITY TO BE FAMILIAR WITH THE APPLICABLE CLAUSES AND PROVISIONS. THE CLAUSES MAY BE ACCESSED IN FULL TEXT AT THESE ADDRESSES: WWW.ARNET.GOV AND WWW.ACQ.OSD.MIL. THIS IS A SMALL BUSINESS SET ASIDE COMPETITIVE ACTION; SIC CODE 7353/NAICS CODE 532412/SIZE STANDARD: $6M. THE COMMAND NAVY REGION NORTH EAST REQUESTS RESPONSES FROM QUALIFIED SOURCES CAPABLE OF PROVIDING THE FOLLOWING FOR THE PERIOD OF PERFORMANCE 10/15/03 THROUGH 10/14/04: ITEM 0001?2 EACH 66FT TELESCOPIC, STICK DRIVEN, 4WD DIESEL POWERED BOOM TRUCKS WITH FOAM OR POLY NAIL FREE TIRES WHICH SHALL CONFORM TO THE FOLLOWING REQUIREMENTS: REACH PLATFORM HEIGHT 66 FEET, HORIZONTAL OUTREACH 56 FEET 9 INCHES SWING 360 DEGREES CONTINUOUS PLATFORM ROTATOR 180 DEGREES HYDRAULIC JIB RANGE OR ARTICULATION 6 FEET 130 DEGREES DIMENSIONAL DATA PLATFORM SIZE 36X72 INCHES OVERALL WIDTH 8 FEET TAILSWING 3 FEET 9 INCHES STOWED HEIGHT 8 FEET 5 INCHES STOWED LENGTH 33 FEET 6 INCHES WHEELBASE 8 FEET 1 INCH GROUND CLEARANCE 12 INCHES GROSS VEHICLE WEIGHT 27000 POUNDS CHASSIS DRIVE SPEED 4 WD 4.0 MPH GRADEBILITY 4 WD 45% TURNING RADIUS INSIDE/OUTSIDE 5 FEET 5 INCHES 11 FEET 4 INCHES POWER SOURCE DIESEL ENGINE 65 HP FUEL TANK CAP 39 GALLONS HYDRAULIC RESERVOIR 31 GALLONS AUX POWER 12 VDC: JLG MODEL 660SJ OR EQUAL. TEST CERTIFICATION REQUIREMENTS FOR RENTAL ELEVATING EXTENDABLE BOOM PERSONNEL LIFTS-STATIC TEST AT 150% OF RATED CAPACITY 1. ON LEVEL GROUND WITH BOOM AT OR NEAR MINIMUM EXTENSION ATTACH TEST WEIGHT TO THE BASKET SUCH THAT THE WEIGHT WILL BE SUSPENDED 6? TO 8? OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS CHOICE. USING THE GROUND CONTROLS, RAISE THE BOOM TO HORIZONTAL (STILL AT A MINIMUM EXTENSION). EXTEND BOOM TO MAXIMUM LENGTH. HOLD 10 MINUTES. ROTATE THE BOOM AND TEST WEIGHT 360 DEGREES, OR AS MUCH AS POSSIBLE. LOWER THE WEIGHT. DRIFT TEST AT 150% OF RATED CAPACITY ON LEVEL GROUND WITH THE BOOM AT OR NEAR MINIMUM EXTENSION, ATTACH TEST WEIGHT TO THE BASKET SUCH THAT THE WEIGHT WILL BE SUSPENDED 6? TO 8? OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS C HOICE. USING THE GROUND CONTROLS, RAISE THE BOOM TO HORIZONTAL (STILL AT MINIMUM EXTENSION). MEASURE AND RECORD THE BASKET (OR LOAD) VERTICAL HEIGHT AT 0, 10, AND 20 MINUTE INTERVALS. MEASURE VERTICAL DRIFT TO THE NEAREST 1/8INCH. MARK AND MEASURE RETRACTION OF BOOM LIFT CYLINDER TO THE NEAREST 1/16INCH TO DETERMINE IF RADIAL MOVEMENT OF LOAD WOULD EXIST. VERTICAL DRIFT SHALL NOT EXCEED ? INCH BETWEEN THE 10 AND 20 MINUTE INTERVALS. LOWER TEST WEIGHT TO GROUND. BOOM TEST AT 150% OF RATED CAPACITY. ON LEVEL GROUND WITH BOOM AT OR NEAR MINIMUM EXTENSION, ATTACH TEST WEIGHT TO THE BASKET SUCH THAT THE WEIGHT WILL BE SUSPENDED 6? TO 8? OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS CHOICE. USING THE GROUND CONTROLS, RAISE THE BOOM TO HORIZONTAL (STILL AT MINIMUM EXTENSION). EXTEND BOOM TO ITS MAXIMUM LENGTH. BOOM UP TO REDUC E THE RADIUS BY FIVE (5) FEET. TELESCOPE IN TO REDUCE BOOM LENGTH BY TEN FEET. LOWER LOAD TO THE GROUND. EMERGENCY POWER SYSTEM TEST AT 100% OF RATED CAPACITY. ON LEVEL GROUND WITH BOOM AT OR NEAR MINIMUM EXTENSION, ATTACH TEST WEIGHT TO THE BASKET SUCH THAT THE WEIGHT WILL BE SUSPENDED 6? TO 8? OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS CHOICE. EXTEND THE BOOM ? MAXIMUM LENGTH. EXTEND THE BOOM ? MAXIMUM LENGTH. SHUT OFF MAIN ENGINE. SWITCH OVER TO EMERGENCY SYSTEM AND DEMONSTRATE THE MACHINE?S ABILITY TO GO TO A SAFE CONDITION. 5 DEGREE MULTI-AXIS SLOPE SENSOR AND WARNING LIGHT TEST WITH ZERO TEST WEIGHT LOAD. HAVE A MECHANIC OPEN THE CONTROL BOX LOCATED INSIDE ENGINE COMPARTMENT. OPERATOR SHALL CONTROL THE FUNCTIONS OF THE MANLIFT FROM THE BASKET DURING THIS TEST. EXTEND BOOM APPROZIMATELY ? OF FULL LENGTH AND RAIS E BASKET APPROXIMATELY 15 FEET.OFF THE GROUND. DEPRESS OR TILT THE SLOPE SENSOR MECHANISM LOCATED INSIDE THE CONTROL BOX. ASSURE ALL FUNCTIONS EXCEPT TRAVEL DO NOT OPERATE IN THIS CONDITION AND/OR THAT THE WARNING LIGHT LOCATED ON THE BASKET CONTROL PANEL COMES ON. SHUT OFF THE ENGINE, AGAIN DEPRESS SLOPE SENSOR MECHANISM. DEMONSTRATE THE ABILITY TO GO TO A SAFE CONDITION USING THE EMERGENCY POWER SYSTEM. WARNING LIGHT ON BASKET CONTROL PANEL WILL NOT COME ONE. TRAVEL TEST ZERO TEST WEIGHT LOAD TRAVEL THE MACHINE IN BOTH DIRECTIONS OVER A DISTANCE AT LEAST EQUAL TO THE LENGTH OF THE MACHINE, IN HIGH SPEED MODE. REPEAT STEP 1 IN LOW SPEED. PRICE TO INCLUDE DELIVERY, MAINTENANCE, REPAIR, OSHA TEST CERTIFICATION DOCUMENTS. THE FUNCTIONAL EQUIPMENT IS REQUIRED F.O.B. DESTINATION BY 15 OCTOBER 2003. INSPECTION AND ACCEPTANCE WILL BE AT DESTINATION. PLACE OF DELIVERY IS NRMD, NA VAL SUBMARINE BASE NLON, GROTON, CT. 06349. QUOTATION SHALL INCLUDE AS A MINIMUM: UNIT PRICE FOB DESTINATION, A POINT OF CONTACT NAME AND PHONE NUMBER, PAYMENT TERMS, AND ALL PROVISION INFORMATION CALLED FOR IN 52.2123-3. THE FOLLOWING FAR PROVISIONS AND CLAUSES ARE APPLICABLE TO THIS PROCUREMENT: 52.211-6 BRAND NAME OR EQUAL. 52.212-1 INSTRUCTIONS TO OFFERORS-COMMERCIAL ITEMS. 52.212-3 OFFEROR REPRESENTATIONS AND CERTIFICATIONS-COMMERCIAL ITEMS. 52.212-4 CONTRACT TERMS AND CONDITIONS-COMMERCIAL ITEMS. 52.212-5 CONTRACT TERMS AND CONDITIONS REQUIRED TO IMPLEMENT STATUES OR EXECUTIVE ORDERS-COMMERCIAL ITEMS (CLAUSES CHECKED UNDER 52.212-5 (ALTI) ARE 52.222-21, 52.222-26, 52.222-35, 52.222-36, 52.222-37, 52.232-33. ALL CLAUSES SHALL BE INCORPORATED BY REFERENCE IN THE RESULTANT ORDER. ADDITIONAL CONTRACT TERMS AND CONDITIONS APPLICABLE TO THIS PROCUREMENT ARE DFAR 252.212-7001 CO NTRACT TERMS AND CONDITIONS REQUIRED TO IMPLEMENT STATUES OR EXECUTIVE ORDERS APPLICABLE TO DEFENSE ACQUISITIONS OF COMMERCIAL ITEMS (NO CLAUSES CHECKED) 252.204-7001 COMMERCIAL AND GOVERNMENT ENTITY (CAGE) CODE, 252.204-7004 REQUIRED CENTRAL CONTRACTOR REGISTRATION, DOD WILL NO LONGER AWARD CONTRACTS TO CONTRACTORS NOT REGISTERED IN THE CENTRAL CONTRACTOR REGISTRATION (CCR) DATABASE. REGISTRATION MAY BE DONE BY ACCESSING THE CCR WEB SITE AT HTTP://WWW.CCR.GOV. A PAPER REGISTRATION FORM MAY BE OBTAINED FROM THE DD ELECTRONIC COMMERCE INFORMATION CENTER AT 800-334-3414. NO NUMBERED NOTES APPLY. THIS ANNOUNCEMENT WILL CLOSE NOON AT CONNECTICUT TIME ON 09 OCTOBER 2003. ALL RESPONSIBLE BUSINESS SOURCES MAY SUBMIT A QUOTATION WHICH SHALL BE CONSIDERED BY THE AGENCY.
- Record
- SN00447557-W 20031005/031003213204 (fbodaily.com)
- Source
-
FedBizOpps.gov Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |