SOURCES SOUGHT
23 -- Manufacture Dune Buggy--El Centro, CA The correct Solicitation Number should read BFQ040012 in lieu of BGQ040012
- Notice Date
- 2/4/2004
- Notice Type
- Sources Sought
- Contracting Office
- BLM CA DESERT DISTRICT OFFICE 22835 CALLE SAN JUAN DE LOS LAGOS MORENO VALLEY CA 92553
- ZIP Code
- 92553
- Solicitation Number
- BFQ040012
- Response Due
- 2/18/2004
- Archive Date
- 2/3/2005
- Point of Contact
- Judy Holden-Hughes Purchasing Agent 9096975200 judy_holden@blm.gov;
- E-Mail Address
-
Email your questions to Point of Contact above, or if none listed, contact the IDEAS EC HELP DESK for assistance
(EC_helpdesk@NBC.GOV)
- Small Business Set-Aside
- Total Small Business
- Description
- Code: 23 - Ground Effect Vehicles, Motor Vehicles, Trailers and Cycles NAICS Code: 42110 - Vehicles, recreational, wholesaling The Burerau of Land Management, El Centro Field Office, located in El Centro, Ca has a requirement for a Dune Buggy w/Basic Enclose Trailer, should have the capablity of traveling long distances in the Imperial Sand Dunes Recreation Area in support of monitoring activities requires by law. SPECIFICATIONS: Line item 1 Frame: Note the Radio, microphone, and all electrical switches must be easily reachable, accessible, and visible by the strapped in seated driver. (1) Frame shall be constructed with 1 1/2 inch 4130 round tube. The diagonal frame supports shall be constructed of 1 inch 4130 tube. (2) Wheel base will be a max. of 1 1/2 inches. (3) Frame will be of the rear engine design. (4) Maxium overall width of 79 inches at the front wheels and 93 inches at the rear wheels. (5) Frame shall seat a driver, and four passengers. (6) Overall length shall be 13 feet 6 inches. (7) Roll cage integrity shall consist of six primary up rights per side. Ground clearance shall be a min. of 18 inches. (9) Door opening on both sides shall be 30 inches by 30 inches. (10) Door opening step in height shall be 30 inches (adjustable if needed). (11) Distance from the floor botton to the top of the cage shall be 43 inches. (12) Aluminum floor. (13) .090 aluminum roof. (14) Rear seat shall be of bench type, 52 inches in length, and seat three persons. (15) Wink mirror. (16)Contractor shall supply a lighted buggy whip. The frame shall have a whip antenna mounted on a portion of the roll cage. The mount shall have electric wire supplied so a lighted whip may be installed. The whip base will be either foldable or quick disconnect design. Whip flag shall meet the regulations for the Imperial Sand Dunes Recreation Area regulations. (17) Frame shall be powder coated green. (18) Adjustable suspension for payloads up to 3,000.0 (1.5 tons) pounds. Engine Specs: (1) Acura/Honda 3.51 V6 (2) HiTorque stater. (3) Mendelola transaxle. Transmission: (1) VW bus with after market gears; ring and pinon 5.42, 1st gear 2.90, 2nd gear 2.14, 3rd gear 1.59 and 4th gear 1.25. (2) 930 CV's with Kartek cages Suspension:(1)Drive train shall be rear engine independent rear suspension. (2) Front susupension shall be independent double A-arm 2 1/2 inch King shocks or equivalent, with air bag type spring, field load carry adjustable, for up to 17 inches of travel. (3) Rear suspension shall be independent trailing arm, 2 1/2 inch shock, airbag type spring, field load carry adjustable for up to 18 inches travel. (4) Sway-a-way axles. (5) On board air pump with gauge visisble from drivers seat for field adjustability. Steering Spec: (1) Power assist rack & pinion. Electricl Spec: (1) Power system capable of operating stock vehicle system and Government supplied lights, radio and other electrical equipment. There shall be 2 "lighter" type power supplies mounted on the instrument panel. (2)Manufacturer will mount this equipment to ensure the controls can be reached by the driver when seat belted in operating position and the equipment is not in the way when entering and wxisting the vehicle. (3) Dome light built in. (4) Six 100 watt off road lights. (5) At least 2 red tail and brake ligths. Gauges: (All guges/lights shall be visible from the strapped in seated driver) (1) Coolant temperature gauge. (2) Oil pressure warning red ligjt with lable. (3) Charge warning red light with label. (4) Volt meter. (5) The buggy shall have an hour meter and it shall be wired so that if it is unhooked the engine will not run. Fule Tank: (1) Minimum of 17 gallon fuel capacity. Tires and Rims: (1) Front-15 x 5.75 aluminum CMS, tire 9.5 x 15 implement for max. low speed steering. (2) Rear-15 x 15 CMS H.D. aluminum with Vari-Trac Sand Tire Unlimited for max. flotation. Brakes: (1) Rear 4 piston caliper Micro stub style. (2) Kariek Micro Stub hub brake or equivalent. (3) Stainless brake lines. (4) Dual handle CNC or equivalent turning brakes mounted in the center of the buggy. (5) CNC pedals. Seat Belts: (1) Will be of the four point harness design with a three inch lap belt and three inch shoulder sections. Seats: (1) Driver seat will be adjustable. (2) Two bucket tube frame suspension type, beard style + 2" wide. Elevated cab forward design, capable of knee room for a 6'3" adult. Rear bench seat capable of seating three adults. Line item 2 Enclosed Trailers shall have 2 axles, w/trailer brakes. If you have any questions, please contact Judy Holden-Hughes at 909 697-5254.
- Web Link
-
Please click here to view more details.
(http://ideasec.nbc.gov/ecprod/owa/ec$cbd.sypfirstcount?P_SERVER_ID3=LM142201&P_OBJ_ID1=623778)
- Place of Performance
- Address: El Centro, Ca
- Zip Code: 92243
- Country: us
- Zip Code: 92243
- Record
- SN00515862-W 20040206/040204212555 (fbodaily.com)
- Source
-
FedBizOpps.gov Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |