SOLICITATION NOTICE
10 -- SOLE SOURCE PROCUREMENT MANDUS GROUP NITROGEN INTENSIFIER AND OIL TRANSFER UNITS
- Notice Date
- 5/28/2010
- Notice Type
- Presolicitation
- NAICS
- 333913
— Measuring and Dispensing Pump Manufacturing
- Contracting Office
- TACOM Contracting Center - Rock Island (TACOM-CC), ATTN: AMSTA-AQ-AR, Rock Island Arsenal, Rock Island, IL 61299-7630
- ZIP Code
- 61299-7630
- Solicitation Number
- W52H09-10-R-0078
- Response Due
- 7/31/2010
- Archive Date
- 9/29/2010
- Point of Contact
- Sue A Burton, 309-782-6759
- E-Mail Address
-
TACOM Contracting Center - Rock Island (TACOM-CC)
(sue.a.burton@us.army.mil)
- Small Business Set-Aside
- N/A
- Description
- This solicitation will result in a sole source firm fixed price Three (3) Year Indefinite Delivery Indefinite Quantity Contract to Mandus Group, CAGE: 1MV66, of the Nitrogen Intensifier, NSN: 1025-01-473-8886, and two Oil Transfer Units NSN: 4933-01-525-9027, AND NSN: 4933-01-572-0092. Estimated out years requirements are Year One-35,50, and 4 each respectively; Year Two-35,50, and 5 each respectively; Year Three-50,50, and 5 each respectively. Minimum Guaranteed quantities are 75, 75, and 4 each respectively. Contract mamimums are 250,250, and 30 each respectively. NAICS code is 333913. The items are for use on the M198, M177, and M119 Howitzers. Estimated issue date is 15 Aug 2010. General Descriptions: The Nitrogen Intensifier is used to assist the military in filling recoil mechanisms, equilibrators, or other nitrogen-filled vessels. It is designed to utilize and intensify all but 150 psi of nitrogen from a supply bottle. It accepts nitrogen from a supply source, intensifies the nitrogen by means of a hydraulic pump and electric motor, and then forces the intensified nitrogen into an accepting vessel of the recoil or equilibrator. The Nitrogen Intensifier shuts down when 150 psi or less is left in the supply bottle, or at a customer-desired upper level pressure. Specifications: Ambient temperature not to exceed 110 degree F or be less than 5 deg F during operation. Maximum pressure is not to exceed 2500 PSI. Minimal electrical service is to be single phase 115 VAC, 60 Hz, 20 Amps. Low end pressure switch is 150 PSI +/- 50 PSI. High-end pressure switch 1850 PSI +/- 50 PSI. Mystik Oil Aw/Al hydraulic oil 100, Oil temp not to exceed 150 degrees F. Unit to be set flat and stationary during operation. The Nitrogen Intensifier should include quick disconnects for all hoses and fittings, a 15 foot nitrogen hose, inlet connection inch female quick connect, outlet NPT male quick disconnect, with a hand-held ON/OFF pendant switch, built-in pressure gage. Pressure relief valve set 2100 PSI +/- 50 PSI. Approximate weight 170 lbs. +/- 5 lbs. Approximate size is 20 feet W X 231/2 inches D X 15 inches H. The system must be portable and run on electricity. The Oil Transfer System, for use on the M777A2 Howitzer and the M119A2 Howitzer, is for use as alternatives to the M3 Oil pump. It provides.59 GPM of oil flow for ease in filling reservoirs, recoil mechanisms, buffers and replenishers. It will self-purge the systems and lines of air, prior to pumping oil, and to accept oil from pressurized systems through the same lines from which they discharge. Oil must flow in either direction through a high-pressure filter, from a pressurized system or to a pressurized system or reservoir.
- Web Link
-
FBO.gov Permalink
(https://www.fbo.gov/notices/654b9b69e0d1896ca9c7a62d4b2555ff)
- Place of Performance
- Address: TACOM Contracting Center - Rock Island (TACOM-CC) ATTN: AMSTA-AQ-AR, Rock Island Arsenal Rock Island IL
- Zip Code: 61299-7630
- Zip Code: 61299-7630
- Record
- SN02163875-W 20100530/100528235818-654b9b69e0d1896ca9c7a62d4b2555ff (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |