SOLICITATION NOTICE
20 -- DRYDOCK & REPAIRS FOR CGC AMBERJACK AND CGC STURGEON
- Notice Date
- 6/29/2012
- Notice Type
- Presolicitation
- NAICS
- 336611
— Ship Building and Repairing
- Contracting Office
- Department of Homeland Security, United States Coast Guard (USCG), USCG Surface Forces Logistics Center (SFLC) Procurement Branch 1, 300 East Main Street, Suite 600, Norfolk, Virginia, 23510-9102, United States
- ZIP Code
- 23510-9102
- Solicitation Number
- HSCG80-13-R-P45003
- Point of Contact
- Nancy M Brinkman, Phone: 757-628-4579, Louis J Romano, Phone: (757)628-4651
- E-Mail Address
-
Nancy.M.Brinkman@uscg.mil, louis.j.romano@uscg.mil
(Nancy.M.Brinkman@uscg.mil, louis.j.romano@uscg.mil)
- Small Business Set-Aside
- Service-Disabled Veteran-Owned Small Business
- Description
- The United States Coast Guard, Surface Forces Logistics Center, Detachment Norfolk VA, intends to issue a Commercial Request for Proposal (RFP) for Dry-dock and repairs to the CGC AMBERJACK (WPB-87315) and CGC STURGEON (WPB-87336) both 87-Foot Patrol Boats. The NAICS Code is 336611. The Coast Guard intends to conduct the procurement in accordance with Federal Acquisition Regulation (FAR) Part 12, Acquisition of Commercial Items, and FAR Part 15, Contracting by Negotiation for Certain Commercial Items. The simplified acquisition will be issued as a Service Disabled Veteran Owned Small Business Set-Aside. Request for Proposals (RFP) will be issued on or about June 29, 2012. The acquisition is to perform drydock and repairs to the CGC AMBERJACK and CGC STURGEON. The vessels are geographically restricted to a facility located within an area no greater than 1200 nautical miles one-way and 2400 nautical miles roundtrip from Galveston, TX. The Period of performance for CGC AMBERJACK is one-hundred twenty three (123) calendar days from 29 OCT 2012 through 1 March 2013. August through 12 October 2012. The Period of performance for CGC STURGEON is fifty-eight (58) calendar days from 4 April through 31 May 2013.. All work will be performed at the contractor's facility within the geographical restriction as stated above. The solicitation will be issued electronically via the Federal Business Opportunity web page at http://www.fedbizopps.gov. It is incumbent upon contractors to monitor the FEDBIZOPS web page for the RFP release and all subsequent amendments. Hard copies of the specification and solicitation will not be issued. The scope of the acquisition is for the overhauling, renewing and repairing of various items aboard the CGC AMBERJACK and CGC STURGEON. This work may include, but is not limited to: 1. Perform Ultrasonic Thickness Measurements 2. Perform Ultrasonic Thickness Measurements 3. Overhead Surfaces (Port Lazarette), Preserve, Insulate 4. Bilge Surfaces (Engine Room), Preserve 100% 5. Preserve Bilge Surfaces 100%, Renew Galley & Mess Deck 6. Dirty Oil Tank, Clean and Inspect 7. Oily Water Tank, Clean, Inspect and Preserve 8. Tanks (MP Fuel Service), Clean and Inspect 9. Tanks (Potable Water), Clean and Inspect 10. Forepeak, Inspect and Preserve 100% 11. Superstructure, Preserve 100% 12. Pilothouse Deck (Aluminum), Inspect, Preserve, and Renew Electrical Matting 13. Depth Sounder, Capastic Fairing, Renew 14. Main Engine/Reduction Gear, Realign 15. Propulsion Shafts, Remove, Inspect, and Reinstall 16. Propulsion Shaft, Repair 17. Propulsion Shaft, Straighten 18. Intermediate Water-Lubricated Shaft Bearing, Renew 19. Aft Water-Lubricated Shaft Bearing, Renew 20. Intermediate Bearing Carrier, Renew 21. Aft Bearing Carrier, Renew 22. Stern Tubes, Interior Surfaces, Preserve 100% 23. Stern Tubes, Interior Surfaces, Repair 24. Propellers, Remove, Inspect, and Reinstall 25. Propeller, Minor Repair and Recondition, Perform 26. Fathometer Transducer, Renew 27. Speed Log, Skin Valve, Clean and Inspect 28. Sea Water System (Valves, Strainers, Piping), Clean, Inspect, and Repair 29. Rudder Assemblies, Remove, Inspect and Reinstall 30. RHIB Notch Skid Pads, Inspect 31. RHIB Notch Skid Pad Studs, Renew 32. Stern Launch Door, Remove, Inspect, and Reinstall 33. Grey Water Holding Tank, Clean and Inspect 34. Sewage Holding Tank, Clean and Inspect 35. Grey Water Piping, Clean and Flush 36. Sewage Piping, Clean and Flush 37. Decks-Exterior (Main Deck), Preserve 100% 38. U/W Body, Preserve 100% 39. Hull Plating Freeboard, Preserve 100% A CD-ROM containing all applicable drawings will be sent via U.S. mail, if requested. Send all requests to Nancy.M.Brinkman@uscg.mil The CD-ROM sets are available of all cutters and will be free of charge to contractors upon request. The CD-ROM(s) contain WINDOWS compliant raster/vector formats (e.g.*.DWF, etc). Proposals are due on or about July 30, 2012 at 10:00 a.m. Eastern Standard Time and may be sent via: Email: nancy.m.brinkman@uscg.mil or mailed to US Coast Guard SFLC/C&P1/PBPL Attn: Nancy Brinkman 300 East Main Street, Suite 600 Norfolk, VA 23510-9102
- Web Link
-
FBO.gov Permalink
(https://www.fbo.gov/spg/DHS/USCG/COUSCGMLCA/HSCG80-13-R-P45003/listing.html)
- Place of Performance
- Address: CONTRACTOR'S FACILITY WITHIN THE SPECIFIED GEOGRAPHICAL RESTRICTION, United States
- Record
- SN02790242-W 20120701/120629234602-ca1f93aee09ae6cb6615b46e86d7a0e9 (fbodaily.com)
- Source
-
FedBizOpps Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |