USPFO for Tennessee, P.O. Box 40748, Powell Avenue, Nashville, TN 37204-0748

Y -- CONSTRUCT VEHICLE MAINTENANCE/AIRCRAFT SUPPORT (AGE) COMPLEX FOR THE TENNESSEE AIR NATIONAL GUARD, MEMPHIS INTERNATIONAL AIRPORT, MEMPHIS, TENNESSEE SOL DAHA40-95-B-0008. DUE 071595. Contact Major Kathryn M. Fulkerson, Contract Specialist, 615/532-3217, or LTC James L. Coonce, Contracting Officer, 615/532-3217. Provide labor, materials, equipment and other services necessary to construct a 17,600 SF structure which houses administrative facilities, library/research/tools/parts area, toilet facilities, mechanical/electrical building equipment areas, battery charging area, bulk storage, a machine shop, four repair bays, a refueler maintenance bay, and outside wash area, and covered storage. The new vehicle maintenance facility will include specialized systems used in the maintenance of the base non-AGE equipment. The specialized equipment in the facility will include an overhead bridge crane spanning two repair bays, a 10,000 pound two post hoist, specialized vehicle exhaust systems for exhausting vehicles during test running, air and electric drops for vehicle service, 185 lb compressed air system for inflation of tires to 145 lbs, a tire inflation cage for personnel protection in the event of a tire bursting during inflation, oil/water separator modifications to receive non-water materials in the event of a fuel spill, and heating of the repair bay areas. The refueler bay will have in addition to the above specialized systems, specialized fuel leak detection systems, in the air and drain systems. In addition to the higher than normal compressed air systems, specialized fuel leak detection systems in the air and drain systems. In addition to the higher than normal compressed air systems, the refueler bay will also have provisions for Grade D breathing air for personnal working in the refueler systems vehicle. Special provisions for adequate emergency breathing air capacity have been provided in the design. Emergency eye wash/shower capabilities have been provided in this part of the facility. The contractor will also be responsible to provide labor, materials, and pertinent services to perform the work required to demolish three concrete pads of varying size, demolish three small buildings, perform asbestos abatement and demolition of two medium size buildings, and demolition of one larger building. Provide the foregoing to install necessary site utilities, asphalt paved roads, repair of asphalt surface where demolition has occurred, installation of new asphalt surfacing, and landscaping plant materials and sprinkler systems. Additionally the contractor will provide the foregoing to renovate Building 452 AGE complex which includes the demolition of existing exterior and interior walls, construction of new interior partitions, installation of a new bridge crane without interfering with the existing building systems, and installation of three new large overhead doors to serve large vehicles. There is also a requirement for outside covered storage. Due to some of the existing facilities remaining active during the course of construction, some of the work may require phasing in order to minimize disruption to operations. Performance time will not exceed 365 days. The constrution cost range is between $1,000,000.00 and $5,000,000.00. Plans and specifications will be available on or about 15 June 1995. A non-refundable cashiers check or money order is required for the plans and specifications in the amount of $75.00, made out to the Treasurer of the Unites States. The solicitation will be furnished at no charge. Plans and specifications will also be available for review at various plans houses within the state. The project is open to large as well as small business (unrestricted). (145)

Loren Data Corp. http://www.ld.com (SYN# 0122 19950526\Y-0002.SOL)