Contracting Division, P.O. Box 8368, Marine Corps Base, Camp Lejeune, NC 28547-8368

54 -- PREFABRICATED DOUBLE-WIDE TRAILERS SOL M6700196Q9480 DUE 082296. Contact, Joyce Bays, 910-451-3016/Contract Specialist. This is a combined synopsis/solicitation for commercial items prepared in accordance with the format in Subpart 12.6, as supplemented with additional information included in this notice. This announcement is issued as a request for quotation M67001-96Q9480 and constitutes the only solicitation; proposals are being requested and a written solicitation will not be issued. The solicitation document and incorporated provisions and clauses are those in effect through Federal Acquisition Circular 90-37. The standard industrial classification (SIC) code for this unrestricted requirement is 2451 and the small business size standard is 500. ITEM 0001 1 (ea) DESIGN: North Carolina (NC) 24' x 54' modular building (code type 6-non-rated); CRITERIA: for daycare occupancy, State of NC - Department of Insurance, National Electric Code, Uniform Plumbing code, Floor live load-50 psf, Roof live load-20 psf; FRAME: 10'' Jr I beam, hitch, out-rigger 4' On Center (O.C.). FLOOR: 2'' x 6'' floor joist on 16'' centers, 0.040 asphalt bottom board, 3/4'' plywood tongue and groove decking, 1/8'' x 12'' x 12'' block tile or similar roll tile, 20 oz commercial carpet, carpet bar (strip) at tile/carpet line, insulation R-19: WALLS (INTERIOR): 8' wall height, 2'' x 4'' studs on 16'' centers, 2'' x 4'' top plate, 2'' x 4'' bottom plate, 5/8'' fire rated vinyl covered gypsum, 86 linear feet (lf) f partition walls, standard trim package, 4'' vinyl base molding, insulation R-11; WALLS (Exterior): 2'' x 4'' x 8' studs on 16'' centers, 8' ceiling height, 5/8''fire rated vinyl covered gypsum, standard trim package, 4'' vinyl base molding, Insulation R-15, wood or vinyl siding, wood or vinyl trim; ROOF: N.C. truss type roof, Mansard roof design, 1/2'' fire treated plywood sheathing, Sea-spray prefinished gypsum ceiling finish, 30 gage galvanized steel roof covering, 2'' X 6'' roof joist with 5/8'' vinyl covered gypsum on bottom side, Gable end vents, Insulation R-30, 24'' overhang on ends - 12'' overhang on sides; PLUMBING: (2 ea) multiple baths, (1 ea) 10 gallon water heater, (2 ea) child size commodes, (1 ea) handicap elongated commode (adult restroom), handicap grab bars as required (adult restroom), (1 ea) child size mounted lavatory, (1 ea) standard size mounted lavatory, water saver faucets, poly supply plumbing, PVC waste plumbing, (2 ea) exhaust fans sized as required, (2 ea) standard size mirrors; ELECTRICAL: (1 ea) 200 amp single phase load center, 12-2 copper romex with ground, (10 ea) 4-40 fluorescent lights, weather head with wire, Ground fault indicator (GFI) receptacles, junction box with cord set up for alarm, (2 ea) lighted EXIT signs with battery backup, (2 ea) porch lights, (1 ea) emergency light, (20 ea) child proof receptacles, standard receptacles at 12' on center (Construction codes must be in compliance with Federal Guidelines for child care facilities, i.e., all electrical outlets shall be a minimum 54'' above finished floor), (5 ea) 2'' x4'' junction box stubbed through floor (for fire alarm); DOORS: (3 ea) 36'' x 36'' swing gates, (2 ea) 36'' x 80'' steel doors with steel frame with 10'' x 10'' view block; panic hardware for 2 exterior doors, hold open devices for 2 exterior doors, (2 ea) 36'' x 80'' interior pre-hung hollow core doors, exterior doors to have closers and lever handles, 1'' x 4'' trim around doors, interior doors stained and varnished, painted frames, keyed lock sets with a master key; HVAC: (2 ea) 2-1/2 ton central wall hung unit, (2 ea) 10 KW heat strip, fiberglass ceiling supply duct, wall return air system; WINDOWS: (10 ea) 24'' x 60'' vertical slide windows, (bronze frame/tint glass), (10 ea) mini blinds for windows; ACCESSORIES: (1 ea) plexiglass window (i. e., 48'' x 24'' set in wall over diaper change counter), (2 ea) paper towel dispensers, (3 ea) toilet paper dispensers, 12 lf of 36'' base cabinets for food preparation area and diaper change area, 5 lf of 20'' base cabinets for child size sink area, 12 lf of overhead cabinets, (no cabinets over diaper change area), (1 ea) single bowl stainless steel sink, (2 ea) stainless steel bar sinks, (1 ea) water cooler, (1 ea) refrigerator. SEALS - NC, HWC; CONSTRUCTION CODES - NC; ENGINEERING CODES - HWC. ITEM 0002 Same specifications as item 0001 except - WALLS (INTERIOR): 8' wall height, 2'' x 4'' studs on 16'' centers, 2'' x 4'' top plate, 2'' x 4'' bottom plate, 5/8'' fire rated vinyl covered gypsum, 50 lf of partition walls, standard trim package, 4'' vinyl base molding, insulation R-11; PLUMBING: (3 ea) multiple baths, (1 ea) 10 gallon water heater, (4 ea) child size commodes, (1 ea) handicap elongated commode (adult restroom), handicap grab bars as required (adult restroom), (4 ea) metal commode modesty partitions, (2 ea) child size mounted lavatory, (1 ea) standard size mounted lavatory, water saver faucets, poly supply plumbing, PVC waste plumbing, (3 ea) exhaust fans sized as required, (3 ea) standard size framed mirrors; DOORS: (2 ea) 36'' x 80'' commercial steel with steel frame with 10'' x 10'' view block, Panic hardware for 2 exterior doors, hold open devices for 2 exterior doors, (3 ea) 36'' x 80'' interior pre-hung hollow core doors, Exterior doors to have closers and lever handles, 1'' x 4'' trim around doors, interior doors stained and varnished, painted frames, keyed lock sets with a master key, (3 ea) wrist blade handle, ( ea) closure, (3 ea) panic hardware, (3 ea) hold open devices. ACCESSORIES: (3 ea) paper towel dispensers, (5 ea) toilet paper dispensers, 5 lf of 20'' base cabinets for child size sink area, (1 ea) water cooler. FLOOR PLANS AVAILABLE UPON REQUEST. Any deviation from these specifications shall be fully explained. Delivery shall be 02 Jan 97. Delivery, inspection and acceptance shall be at the Marine Corps Air Station, Jacksonville, NC. Award will be based on price and price related factors. The following Federal Acquisition Regulation (FAR) provisions and clauses apply to this acquisition: FAR 52.212-1 Instructions to Offerors-Commercial Items (OCT 1995); FAR 52.212-3, Offeror Representations and Certifications-Commercial Items (OCT 1995); FAR 52.212-4 Contract Terms and Conditions - Commercial Items (OCT 1995); FAR 52.212-5 Contract Terms and Conditions Required to Implement Statutes Or Executive Orders - Commercial Items (OCT 1995), including THE ADDITIONAL FAR clauses CITED WITHIN THE CLAUSE UNDER PARAGRAPH (b)(6) through (10); DFARS 252.212-7001 CONTRACT TERMS AND CONDITIONS REQUIRED TO IMPLEMENT STATUTES OR EXECUTIVE ORDERS APPLICABLE TO DEFENSE ACQUISITIONS OF COMMERCIAL ITEM (NOV 1995) (CLAUSE INCLUDED BY REFERENCE IS 252.225-7001 BUY AMERICAN ACT AND BALANCE OF PAYMENT PROGRAM (41 U.S.C. 10, E.O. 10582) AND 252.225-7000 BUY AMERICAN ACT - BALANCE OF PAYMENTS PROGRAM CERTIFICATE. The offeror is requested to provide their Contractor's Establishment Code (CEC) and Commercial and Government Entity (CAGE) Code with their quote. The CAGE code entered must be for that name and address provided by the Contractor. If the offeror does not have a CAGE code, it may ask the Contracting Officer to request one from the Defense Logistics Services Center (DLSC). Period for acceptance of offers is 30 calendar days. Offerors responding to this announcement shall submit their offers in accordance with 52.212-1 and shall include a completed copy of provision 52.212-3 and 252.225-7000. Closing date 20 Aug 96, 4:00 p.m. Submit quotes to Contracting Division, P.O. Box 8368, MCB, Camp Lejeune, NC 28547-8368. POC: Joyce Bays, (910) 451-3016. (215)

Loren Data Corp. http://www.ld.com (SYN# 0389 19960806\54-0001.SOL)