Contracts Department, P. O. Drawer 43019, MCLB, Albany, GA 31704-3019

J -- REBUILDING OF EIGHT (8) DETROIT DIESEL ENGINES SOL M67004-00-Q-0021 DUE 081600 POC Sgt Sanchez or MSgt Beaulieu, Code 89-1, (912)639-6784 This is a combined synopsis/solicitation for commercial service prepared in accordance with the format in Subpart 12.6, as supplemented with additional information included in this notice. This announcement constitutes the only solicitation; proposals are being requested and A WRITTEN SOLICITATION WILL NOT BE ISSUED. This requirement is being issued as a Request for Quotation. Solicitation document and incorporated provisions and clauses are those in effect through Federal Acquisition Circular 97-13 and Defense Acquisition Circular 91-13. This action is restricted to small businesses. The following service is required to rebuild eight (8), 8V92TA, Detroit Diesel Engines: NSN for engines to be rebuilt is 2815-01-186-7251. The following engine components must be replaced with new parts: pistons/rings, cylinder heads, gaskets/seals, all bearings, and all hoses/tubes. The following components must be completely disassembled, cleaned, and reconditioned to original manufacturer's specifications, reassembled,have required operating tests completed, and inspected: engine assembly, blower, turbo, fuel pump, injectors, oil pump, accessory drive, oil cooler, water pump, air compressor, Jacob's brake, governor, cylinder heads, exhuast manifolds, crankshaft, camshaft set, piston rods, engine block, throttle delay, rack, oil filter assemble, starter, alternator, and all covers/plates, etc. All of the required services shall be done in accordance with the following service manuals: Detroit Diesel Service manual Series 92, Part Number 6SE379, published Sept 1999, RS-08780A-50, TM 2320-34/13 = TM 9-2320-297-34, TM 2320-24P/14 = TM 9-2320-297-24P, TM 9-2815-224-34&P, PAINT BLACK MIL-C-64159 TYPE I. Completed engines must be run on a dyno for load testing and engine performance assurance. Completed engines will be painted in accordance with original manufacturer's specifications as stated in the above listed references. Contractor must be able to complete the above services within 21 days of receipt of engines. Deliveryshall be F.O.B. Destination, MCLB Albany, GA 31704 with inspection/acceptance at destination. Delivery will be coordinated with requesting activity, after award. FAR Clauses/Provisions: 52.203-3, Gratuities, 52.212-1, Instructions to Offerors Commercial Items, 52.222-41 Service Contract Act of 1965, as amended; 52.212-4 Contract Terms and Conditions Commercial Items, 52.212-5 Contract Terms and Conditions Required to Implement Statues or Executive Orders Commercial Items (incorporating 52.222-35 Affirmative Action for Special Disabled and Vietnam Era Veterans, Affirmative Action for Handicapped Workers, 52.222-37 Employment Reports on Special Disabled Veterans and Veterans of the Vietnam Era. The contractor shall extend to the Government the full coverage of any standard commercial warranty normally offered in a similar commercial service, provided such warranty is available at no additional cost to the Government. All work performed under this contract requires a minimum 1 year, 12,000 mile warranty for workmanship and parts. Offerors responding to this announcement must provide the information contained in 52.212-1, Instruction to Offerors Commercial Items. The offeror should also provide its Commercial and Government Entity (Cage) code, Contractor Establishment code (DUNS number) and Tax Identification Number. Contractors must be registered in the Central Contractor Register or accept the Government Credit Card as a form of payment to be eligible for award. If a change occurs in this requirement, only those offerors that respond to this announcement within the required time frame will be provided any changes/amendments and considered for future discussions and/or award. Written quotes and the above required information must be received at this office on or before 16 August 2000, at 2:00 PM Eastern STD. Time. All responsible sources may submit a quote that will be considered by the Marine Corps Logistics Base, Albany, GA, Contracting Dept. FAX (912)639-6791 Posted 08/02/00 (W-SN480981). (0215)

Loren Data Corp. http://www.ld.com (SYN# 0084 20000804\J-0019.SOL)

| J - Maintenance, Repair and Rebuilding of Equipment Index  |  Issue Index |