44 -- INDUSTRIAL BOILER

Notice Date

April 24, 2001

Contracting Office

Fleet & Industrial Supply Center, Regional Contracts Dept, Attn: Bid Officer/Code 210A94, 937 N. Harbor Drive, Suite 212, San Diego, CA 92132-0212

ZIP Code

92132-0212

Solicitation Number

N00244-01-T-0657

Response Due

May 14, 2001

Point of Contact

Contracting Officer @ 619-532-2588; FAX 619-532-2347

Description

IMPORTANT NOTICE: DFARS 252.204-7004 "Required Central Contractor Registration" applies to all solicitations issued on / or after 06-01-98. Lack of registration in the CCR database will make an offeror / quoter INELIGIBLE FOR AWARD. Please ensure compliance with this regulation when submitting your quote. Call 1-888-227-2423 or visit the Internet at http://www.ccr2000.com/ for more information. This is a combined synopsis / solicitation for commercial items prepared in accordance with FAR 13 and the format in FAR subpart 12.6, as supplemented with additional information included in this notice. This announcement constitutes the ONLY solicitation; quotes are being requested and A SEPARATE WRITTEN SOLICITATION WILL NOT BE ISSUED. Solicitation number / RFQ N00244-01-T-0657 applies; an electronic copy of the RFQ can be accessed at http://www.neco.navy.mil. This solicitation document and incorporated provisions and clauses are those in effect through Federal Acquisition Circular 97-23 and DFAR Change Notices effective through 12/13/00. The standard industrial code is 3443 (NAICS code 32512) and the business size standard is 500 employees. This requirement is for a fixed priced contract for two line items as follows. Quotes will be accepted on a "Brand Name or Equal" basis. The following brand name products are known to be acceptable: 1) Hurst Boiler. Line Item 0001: is for a 400 series boiler, #2 OIL FIRED, 150 PSIG PACKAGED BOILER, HAS FIVE SQUARE FEET OF HEATING SURFACE PER BOILER HORSEPOWER, MAINTAINS UNIFORM TEMPERATURE, BOILER TRIM TO CONTAIN: OPERATING, HIGH LIMIT AND PROPORTIONING PRESSURE CONTROLS, PRIMARY LOW WATER CUT-OFF (LWCO) WITH PUMP CONTROL, SECONDARY LOW WATER CUT-OFF (LWCO), PROBE TYPE, 4.5" PRESSURE / TEMPERATURE GAUGE, 0 -- 300 PSIG, 3" STACK THERMOMETER, 1000 D/F, SAFETY RELIEF VALVES SET AT 150 PSIG PER ASME CODE, WATER COLUMN DRAIN VALVE (1"), SURFACE BLOWDOWN: 1 VALVE AND 1 SKIMMER TUBE, FEEDWATER VALVES: 1 STOP AND 1 CHECK, 1.25", BURNER: GODON-PIATT, S8.8 -O- 03, UL, FM AND CSD-1 APPROVALS, #2 OIL, DIRECT SPARK IGNITION, MODULATED FIRING, CONTROL PANEL: REMOTE PANEL (CALIFORNIA CODE), 120 V / 60 Hz / SINGLE PHASE ELECTRICAL CONTROLS, 120 V / 60 Hz / SINGLE PHASE BLOWER, CONTROL PANEL ON BURNER WITH FOUR (4) LIGHTS, ALARM BELL WITH AUTO SILENCER, OTHER FEATURES: HIGH WATER LEVEL ALARM, VENT VALVE, LOW WATER CUT-OFF SHUNT SWITCH, CHEMICAL FEED CONNECTION WIT STAINLESS STEEL NOZZLE, ASSUMPTIONS: INDOOR OPERATION, INSULATION FOR PERSONNEL PROTECTION (BY OTHERS), EXHAUST STACK (BY OTHERS), TWO SETS OF OPERATIONS AND MAINTENANCE MANUALS. ITEM 0002: FM-200-S-150 FEEDMISER, OPEN VENTED, BOILER FEEDWATER / CONDENSATE RETURN SYSTEM, NON-CODE DESIGN, 200 GALLON CAPACITY 34" DIAMETER X 60" LONG DRUM WITH 60" STEELSTAND WITH FLOAT TYPE MAKE-UP, WATER LEVEL GAUGE GLASS SET WITH PROTECTION ROD, TANK DRAIN VALVE, TANK THERMOMETER, SINGLE / VERTICAL / MULTI-STAGE PUMP (5 HP ODP MOTOR @ 220 V / 60 Hz / 3PH WITH STARTER), DESIGNED FOR 150 PSIG DUTY, 22 GPM, TDH OF 360 FT. All items are to be delivered to: Naval Construction Training Center in Port Hueneme CA. The provision at FAR 52.212-1, Instructions to Offerors -- Commercial Items applies. Addendum to FAR 52.212-1, Paragraph (b)(5): Offers shall provide an express warranty which at a minimum shall be the same warranty terms, including offers of extended warranties, offered to the general public. Express warranties shall be included in the contract. Clause 52.212-4, Contract Terms and Conditions -- Commercial Items applies. The clause at 52.212-5, Contract Terms and Conditions Required to Implement Statutes or Executive Orders -- Commercial Items applies with the following applicable clauses for paragraph (b): FAR 52.222-26, Equal Opportunity; FAR 52.222-35, Affirmative Action for Disabled Veterans and Veterans of the Vietnam Era, FAR 52.222-36, Affirmative Action for Workers with Disabilities; FAR 52.222-37, Employment Reports on Disabled Veterans and Veterans of the Vietnam Era. DFARS 252.212-7001, Contract Terms and Conditions Required to Implement Statutes or Executive Orders Applicable to Defense Acquisitions of Commercial Items, applies with the following clauses applicable for paragraph (b): DFARS 252.225-7001, Buy American Act and Balance of Payment Program; and DFARS 252.225-7012, Preference for Certain Domestic Commodities; and FAR 52.211-6, Brand Name or Equal. OFFERORS ARE REQUIRED TO COMPLETE AND INCLUDE A COPY OF THE FOLLOWING PROVISIONS WITH THEIR PROPOSALS: FAR 52.212-3, Offeror Representation and Certifications -- Commercial Items. The government intends to make a single award to the responsible offeror whose offer is the most advantageous to the government considering price and price-related factors. In addition NAVSUP 5252.215-9402, Notice to Prospective Offerors, and 5252.215-9403, Additional Evaluation Factors -- Contractor Evaluation System, Red / Yellow / Green Program applies. Note: The full text of the Federal Acquisition Regulations (FAR) can be accessed on the Internet at www.arnet.gov.far or www.deskbook.osd.mil; Defense Federal Acquisition Regulation Supplement (DFARS) can be accessed on the Internet at www.dtic.mil/dfars. Parties responding to this solicitation may submit their quote in accordance with their standard commercial practices (e.g. on company letterhead, formal quote form, etc.) but must include the following information: 1) Company's complete mailing and remittance addresses, discounts for prompt payment, if any (e.g. 1% 10 days), anticipated delivery / availability of product / s, the company's CAGE code, Dun & Bradstreet Number, and Taxpayer ID number. In addition, if you are quoting on a comparable commercial item, product literature must be included. All FAR certifications and representations specified above must also accompany your quote. Quotes must be received no later than 3:00 PM, local time on 05-14-01, and will be accepted via fax (619-532-2347) or via e-mail (jessica_e_dunker@sd.fisc.navy.mil). Quotes submitted as an attachment to an e-mail should be sent in Word Version 6.0 or higher.

Web Link

click here to download a copy of the RFQ (http://www.neco.navy.mil)

Record

Loren Data Corp. 20010426/44SOL002.HTM (W-114 SN50K1D1)