Y -- FY 01 ROOFING, WATERPROOFING, STRUCTURAL AND PLUMBING RESTORATION FOR HIGH RISE BUILDING, FORT HAMILTON, NY

Notice Date

August 2, 2001

Contracting Office

US Army Corps of Engineers, New York District, Attn: CENAN-CT, 26 Federal Plaza, Rm 1843, New York, N.Y. 10278-0090

ZIP Code

10278-0090

Solicitation Number

DACA51-01-B-0025

Response Due

September 20, 2001

Point of Contact

Jacquelline Daly 212-264-9069

Description

PAY SPECIAL ATTENTION TO NEW REQUIREMENTS FOR REGISTERING ON OUR WEBSITE. The U.S. Army Corps of Engineers intends to procure structural repairs to high rise building 136 and 138 with the possibility or the possible option of buildings 135 and 137. This includes extend foundation waterproofing about 2 feet up to grade level; provide new waterproofing on subgrade corridor roof slabs; provide full waterproofing for full depth of foundation wall. Excavate, backfill, reseed and transplant as required to restore landscaping. Pressure inject chemical grout waterproofing into foundation wall cracks from interior of basement. Waterproof areaways. Replace existing cast-in-place planters with pre-cast planters. Provide sealant at joints between concrete walkways and building walls. At selected basement corridor walls, scrape and paint concrete walls and ceilings. At garage floors, remove deteriorated asphaltic coatings and spalled concrete topping. Shot blast existing concrete, patch topping and prepare to receive new cementitious finish. Paint new parking lines on floor. Paint garage walls and ceiling. At selected beams and columns, remove concrete encasement, perform visual and ulktrasonic inspection of beams and column corrosion and loss of section. Clean corrosion, weld beam and column reinforcements if necessary and inspect welds visually and ultrasonically. Replace concrete encasement. At terraces, remove concrete toppings, waterproof membranes, drains, flashings, railings and parapet copings. Provide new concrete subfill, waterproof membrane and concrete topping. Provide new duplex drains, some at new locations. Provide new flashings. Reinstall existing railing. At windows, remove sealant at sill to jamb joint. Provide new sealant and molding. Inspect window perimeter sealant and EIFS finish. Provide new sealant if existing is missing or defective. Provide new EIFS patch if EIFS is deteriorated at window jamb. At selected roof areas, cut out existing epdm membrane and insulation down to existing wood deck with asphaltic membrane. Remove base flashings, pitchpockets and door sills. Provide new roof insulation with epdm membrane, flashings and pitchpockets. Perform various other repairs to roof including stripping of deteriorated beams, patching of tears, installing battens at areas where epdm membrane has worked loose. At selected bulkhead roofs, replace aluminum coping with new. Replace metal ventilator caps at top of abandoned chimney flues with new. Co-ordinate their replacement with cable TV company. At Buildings 135, 136 & 138, remove existing lobby ventilation exhaust fans and housings at roofs and replace with new. At Building 138, remove existing concrete caps at the top of the lobby ventilation shafts and replace with new fans and housings. At each floor lobby provide fire damper and volume damper at shaft opening. Replace all terrace drains. Replace trench drains in front of garage doors. Remove and replace selected area drains. Replace missing floor drain grates. Replace selected clean outs to make accessible. Remove concrete patching to expose cleanouts. Provide cleanouts at the base of leaders. Provide automatic drain aftercooler in selected condesate pump waste lines. Clean selected waste lines to remove debris. Provide clean out plugs where missing. Provide vent piping as selected locations. The estimated date for the availability of web solicition and is on or about 20 August 2001. The estimated date for bid opening will be on or about 20 September 2001 at 2:00 PM EST at US Army Corps of Engineers, 26 Federal Plaza, Room 1843, New York, NY 10278-0090. The estimated time for project completion will be 365 calendar days. The NAICS code for this project is 233220. To obtain the solicitation document via CD-ROM, mail check or money orders payable to FAO USAED, New York in the amount of $10.00 per set (non-refundable) to US Army Corps of Engineers, 26 Federal Plaza, Room 1843, New York, NY 10278-0090, Attn: Jacquelline Daly. Interested parties requesting the solicitation document CD-ROM should do in writing stating the solicitation no. of the project, complete company's name and address (NO P.O. Box), telephone and facsimile number (including area codes). Plans and specifications will be downloadable free of charge from our website, www.nan.usace.army.mil, on or about 20 August 2001. HOWEVER, TO RECEIVE ANY AMENDMENTS OR UPDATES, CONTRACTORS MUST REGISTER FOR THIS SOLICITATION ON THE AFOREMENTIONED WEBSITE. ANY CONTRACTOR WHO REQUESTS A DISK BUT DOES NOT ALSO REGISTER ON THE WEBSITE WILL NOT BE ISSUED ANY SUBSEQUENT AMENDMENTS ON DISK. TO RECEIVE AMENDMENTS BY DISK, YOU MUST BE REGISTERED AND HAVE PREVIOUSLY SUBMITTED THE $10 FEE. The estimated cost range of the above project is $1,000,000.00 to $5,000,000.00 for all four buildings. If only Building #136 and 138 are solicited, the range is $500,000.00 to $1,000,000.00. This solicitation is UNRESTRICTED. The solicitation document can be viewed at Room 1843, at US Army Corps of Engineer, 26 Federal Plaza, NY, NY 10278; Browns Letter 1167 McBride Avenue, West Paterson, New Jersey; at F.W. Dodge Two Penn Plaza, 10th Floor, New York, NY 10121 or for location at Fort Hamilton Area, contact Technical Manager, William Bendick at 212-264-9098. DFARS 252.204-7004, "Required Central Contractor Registration" ("CCR") applies to this solicitation. Prospective contractors must be registered in the DOD Central Contractor Registration (CCR) database prior to award, otherwise an offeror will be ineligible for award. Information on CCR registration and annual confirmation requirements may be obtained by calling 1-888-227-2423, or via the Internet at <http://www.ccr2000.com>. This announcement and any amendments to this announcement are also published on the internet at http://cbdnet.access.gpo.gov.

Record

Loren Data Corp. 20010806/YSOL005.HTM (W-214 SN50T8H3)